Removal

AIR CONDITIONING: BLOWER UNIT (for Hatchback): REMOVAL

CAUTION:
Some of these service operations affect the SRS airbag system. Read the precautionary notices concerning the SRS airbag system before servicing Service Precautions.

HINT
Use the same procedure for both the RH and LH sides.

1. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL

Wait for at least 90 seconds after disconnecting the cable to prevent the airbag from working.

2. DISCHARGE REFRIGERANT FROM REFRIGERATION SYSTEM Service and Repair

3. DRAIN ENGINE COOLANT Service and Repair

4. REMOVE FRONT WIPER ARM HEAD CAP Removal

5. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY LH Removal

6. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY RH Removal

7. REMOVE HOOD TO COWL TOP SEAL Removal

8. REMOVE COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY Removal

9. REMOVE COWL TOP VENTILATOR LOUVER LH Removal

10. REMOVE FRONT WIPER MOTOR AND LINK Removal

11. REMOVE NO. 2 COWL TO REGISTER DUCT SUB-ASSEMBLY Removal

12. REMOVE COWL TOP PANEL OUTER Removal

13. DISCONNECT SUCTION TUBE SUB-ASSEMBLY Removal

14. DISCONNECT LIQUID TUBE SUB-ASSEMBLY Removal

15. DISCONNECT HEATER WATER OUTLET HOSE A (FROM HEATER UNIT) Removal

16. DISCONNECT HEATER WATER HOSE INLET A Removal

17. BOLTS, SCREWS AND NUTS TABLE Removal

18. REMOVE INSTRUMENT PANEL FINISH PANEL END LH Removal

19. REMOVE INSTRUMENT PANEL FINISH PANEL END RH Removal

20. REMOVE INSTRUMENT CLUSTER FINISH PANEL NO.1 Removal

21. REMOVE COMBINATION METER ASSEMBLY Removal

22. REMOVE INSTRUMENT CLUSTER FINISH PANEL SUB-ASSEMBLY CENTER Removal

23. REMOVE RADIO TUNER OPENING COVER (w/o Radio Receiver) Removal

24. REMOVE RADIO RECEIVER ASSEMBLY Removal

25. REMOVE AIR CONDITIONER PANEL SUB-ASSEMBLY Removal

26. DISCONNECT AIR MIX DAMPER CONTROL CABLE SUB-ASSEMBLY Removal

27. DISCONNECT DEFROSTER DAMPER CONTROL CABLE SUB-ASSEMBLY Removal

28. DISCONNECT AIR INLET DAMPER CONTROL CABLE SUB-ASSEMBLY Removal

29. REMOVE FRONT DOOR OPENING TRIM WEATHERSTRIP RH Removal

30. REMOVE FRONT DOOR OPENING TRIM WEATHERSTRIP LH Removal

31. REMOVE FRONT PILLAR GARNISH RH Removal

32. REMOVE FRONT PILLAR GARNISH LH Removal

33. REMOVE NO. 1 SWITCH HOLE BASE Removal

34. REMOVE GLOVE COMPARTMENT DOOR ASSEMBLY Removal

35. REMOVE UPPER INSTRUMENT PANEL SUB-ASSEMBLY Removal

36. REMOVE FRONT DOOR SCUFF PLATE RH Removal

37. REMOVE FRONT DOOR SCUFF PLATE LH Removal

38. REMOVE INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY RH Removal

39. REMOVE INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY LH Removal

40. REMOVE COWL SIDE TRIM BOARD RH Removal

41. REMOVE COWL SIDE TRIM BOARD LH Removal

42. REMOVE SHIFT LEVER KNOB SUB-ASSEMBLY (for Manual Transaxle) Removal

43. REMOVE SHIFTING HOLE COVER SUB-ASSEMBLY (for Manual Transaxle) Removal

44. REMOVE CONSOLE BOX COVER REAR Removal

45. REMOVE CONSOLE BOX CARPET Removal

46. REMOVE CONSOLE BOX ASSEMBLY REAR Removal

47. REMOVE INSTRUMENT PANEL FINISH PANEL SUB-ASSEMBLY LOWER Removal

48. REMOVE INSTRUMENT PANEL BOX Removal

49. REMOVE NO. 6 HEATER TO REGISTER DUCT ASSEMBLY Removal

50. DISCONNECT ANTENNA CORD SUB-ASSEMBLY Removal

51. SEPARATE HOOD LOCK CONTROL LEVER SUB-ASSEMBLY Removal

52. REMOVE LOWER INSTRUMENT PANEL SUB-ASSEMBLY Removal

53. POSITION FRONT WHEELS FACING STRAIGHT AHEAD

54. REMOVE STEERING PAD Removal

55. REMOVE STEERING WHEEL ASSEMBLY Removal

56. REMOVE STEERING COLUMN COVER Removal

57. REMOVE COMBINATION SWITCH ASSEMBLY Removal

58. DISCONNECT POWER STEERING ECU Removal

59. REMOVE INSTRUMENT PANEL SUB REINFORCEMENT Removal

60. REMOVE COLUMN HOLE COVER SILENCER SHEET Removal

61. SEPARATE STEERING SLIDING YOKE SUB-ASSEMBLY Removal

62. REMOVE BRAKE PEDAL (for Automatic Transaxle) Removal

63. REMOVE BRAKE MASTER CYLINDER PUSH ROD CLEVIS (for Manual Transaxle) Removal

64. REMOVE BRAKE PEDAL SUPPORT (for Manual Transaxle) Removal

65. REMOVE STEERING COLUMN ASSEMBLY Removal

66. REMOVE DEFROSTER NOZZLE ASSEMBLY Removal

67. REMOVE REAR NO. 2 AIR DUCT (for Cold Area Specification Vehicles) Removal

68. REMOVE REAR NO. 1 AIR DUCT (for Cold Area Specification Vehicles) Removal

69. REMOVE REAR NO. 3 AIR DUCT (for Cold Area Specification Vehicles) Removal

70. REMOVE INSTRUMENT PANEL BRACE SUB-ASSEMBLY Removal

71. SEPARATE MAIN BODY ECU Removal

72. SEPARATE CONNECTOR NO. 2 HOLDER Removal

73. REMOVE INSTRUMENT PANEL REINFORCEMENT Removal

74. REMOVE BLOWER UNIT





(a) Remove the 3 screws and the blower unit.