Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Odor Correction
- A/C - Odors
- Spark Plug - Fouling
- Engine - Automatic Valve Lash Adjuster Noise
- Exhaust - Noises When Cold
- Drivetrain - Click, Snap or Clunking Noise From Rear
- Turbocharger - Installation of Water Cooled Unit
- Speedometer/Cable - Chattering/Noisy
- Engine - Stumble/Low Power/Black Smoke
- Rear Wiper/Defogger - Inoperative
- Door Glass - Scratches
- Ventilation System - Cannot Be Regulated With Lever
- Turbocharger - Oil Pipe Leakage
- Window - Chemical Film Build-Up/Fogging
- Paint - Overspray On Body Surfaces
- Scuff Plate - Deformation/Overlap
- Brakes - Judder (vibration) Diagnosis and Repair
- Recommended Repairs
- Superceded Bulletins
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- VIN - Decoding Information
- VIN - Replacement Plate/Label
- VIN - Master Decoder Information
- New Service Bulletin Group Numbers
- A/C - Adding Refrigerant Oil
- A/C - System Leak Checking
- A/C - Odor Correction
- A/C - Handling Precautions For Freon R-12
- A/C - Odors
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Engine - Oil Jet Assemblies in Turbo Short Blocks
- Brakes - Pad Installation Service Points
- Spark Plug - Fouling
- Timing Chain & Tensioner Spring - Parts Available
- Engine - Automatic Valve Lash Adjuster Noise
- Engine - Valve Lash Adjuster Cleaning Procedure
- Piston Pin - Installation Tool Instructions
- Engine - Cylinder Block Distortion Limit Specification
- Silent Shaft Chain Tensioner Bolt - Torque Update
- Engine - Piston Pin Installation Tool
- Tools - Piston Pin Tool Operating Instructions
- Exhaust - Noises When Cold
- Exhaust Manifold - Replacement
- Front Cross Member - Removal
- Wheel - Balancing Accuracy Tips
- Wheels - Lug Nut Torque Information and Chart
- Urethane Bumpers - Painting Process
- Interior - Wind Noise Diagnosis
- M/T Clutch - Judder
- LS Differential - Oil/Lubrication Recommendations
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- Clutch Release Cylinder - Repair Kit
- Clutch Pedal - Height Specification Change
- Clutch Pedal - Engagement Point Adjustment
- Engine Controls - Never Use a Test Light To Check an ECM
- Drivetrain - Click, Snap or Clunking Noise From Rear
- Brakes - Push Rod Clearance Specifications
- Battery - Care During Long Term Storage
- Battery - Application Guide/Cold Cranking Amp Specs.
- Alternator - Damaged Harness Replacement
- ECI System - Voltmeter Check Procedure
- Turbocharger - Installation of Water Cooled Unit
- Turbocharger - Component Availability/Replacement
- Accelerator Cable - Adjusting Nut Torque Specification
- Rear Window Defogger - Repair
- Windows - Repair of Rear Defogger Grid
- Rear Window Defogger Grid - Repair
- Brakes - Rotor Service Procedures
- ECI System - Manual Update
- Speedometer/Cable - Chattering/Noisy
- Headlamp Linkage - Service Procedures
- Antilock Brake System - Diagnosis
- Steering Wheel - Off Center Diagnosis
- Synthetic Resin Parts - Heat Resistance Specifications
- VIN - Codes
- Body - Noise Diagnosis
- Communications Devices - Installation Precautions
- Tools - Fault Codes When Using the Multi-Use Tester
- Emission - Control Information Label Ordering
- Emissions - Correct Diagnosis of Emission Control Parts
- Engine Controls - DTC P0441
- Engine - Stumble/Low Power/Black Smoke
- Tools - Multi-Use Tester ROM Pack Usage
- Tool - Multi-Use Tester Application Chart
- Tools - Multi-Use Tester ROM Pack Usage
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Audio - Speaker Troubleshooting Manual Supplement
- Rear Wiper/Defogger - Inoperative
- Windshield - Installation Instructions
- Door Glass - Adjustment and Guide
- Door Glass - Scratches
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- A/T - Recommended Fluid
- Transmission - Identification Codes
- A/T - New End-Play and Preload Measurement
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Identification
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Repair Procedure Updates
- Transmission Deceleration Sound
- M/T - Flywheel Surfacing Limit
- Brakes/AT - Fluid Recommendations
- Automatic Transmission - Fluid Recommendations
- Ventilation System - Cannot Be Regulated With Lever
- Turbocharger - Oil Pipe Leakage
- Turbocharger - Oil Feed Pipe Parts Available
- Spark Plug Cable - Proper Routing
- Pusher Fan For A/C Condenser - Manual Update
- Crankcase - Drain Plug Gasket
- Campaign - Cam Bore Plug Sealing
- Window Shade Kit - Repairs
- Instrument Pad - Mounting Points
- Wiring Diagrams - Service Manual Corrections
- Chemicals - Fuel Injector Cleaner Feels 1/2 Full
- Cruise Control - Updates
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Remote Keyless Entry - Update
- Roof-Mounted Antenna - Hole Template
- Seat Belt - Rear Shoulder Belt Installation
- Interior - Buzz, Squeak, and Rattle Kit
- Window - Chemical Film Build-Up/Fogging
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Paint - Overspray On Body Surfaces
- Paint - Damage Identification and Repair
- Paint Codes - Applications and Cross Reference
- Modulator - Rear Brake Lock-Up Control System
- Water Temperature Switch - Torque Specification
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- A/C Refrigerant - Service Information
- Overview
- Refrigerants and Their Availability
- System Differences
- Refrigerant Differences
- Lubricant Differences
- Retrofitting Systems
- Recovery and Recycling of Refrigerants
- Storing Recycled Refrigerant
- Transferring Recycled Refrigerant
- System Flushing
- Typical Cause of A/C System Contamination
- Mixing Refrigerants
- Contaminated Service Equipment
- Disposing of Contaminated Refrigerant
- Scuff Plate - Deformation/Overlap
- Brakes - Proportioning Valve Precaution Update
- M/T - Fluid Recommendation/Caution
- US Repair Supplies - Lubricants, Sealers, Cleaners Etc.
- Brakes - Judder (vibration) Diagnosis and Repair
- A/C - Refrigerant Temperature Switch Manual Correction
- Propane-Assisted Idle - Adjustment
- Engine - Pinging Condition
- Engine - Jet Valve Clearance Change
- A/C - Refrigeration Oil Specification
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Lighting - Headlamp Moisture Information
- Alignment - Two Wheel Vs. Four Wheel